STANDARD AND LONG TERM STORAGE （标准和长期存储）.pdfVIP

SECTION 10 COMMERCIAL Peerless Pump Company Page 12 TECHNICAL POLICY Indianapolis, IN 46207-7026 June 27, 2007 STANDARD AND LONG TERM STORAGE Standard Packaging 1) This is suitable for protection during shipment and during covered storage at jobsite for a short period between installation and start-up. The preservatives applied at the factory have an effective life of three (3) months (plus/minus) from date of domestic shipment depending on the severity of the environment in which the equipment. For international destination this will vary depending on the sea worthiness of export boxing. Recommended Storage Atmosphere 1) Controlled storage facilities should be maintained at and even temperature 10 degrees F or more above the dew point with relative humidity less than 50% and little or no dust. If these requirements cannot be met the pump is to be considered in uncontrolled storage. 2) For uncontrolled storage periods of six (6) months or less, the equipment is to be inspected weekly to insure that all preservatives are intact and internals are protected. 3) Inspect and recoat periodically the equipment with water displacement rust inhibitors (VPCI-368-021 (Rust-Ban 392 or equal) crusting grease (Rust-Ban 326 or equal), vapor phase inhibitor (Shell VPI- 260 or equal), rust preventative coating (Rust-Ban 373 or equal). Uncontrolled Storage Moisture Protection 1) All pipe threads and flanged pipe covers are to be sealed with tape. Furthermore you should place 10 pounds of moisture absorbing desiccant or 5 pounds of vapor phase inhibitor crystals near the center of pump. 2) If the pump is assembled, place an additional one pound in the discharge o