电泳涂漆工安全操作规程.docVIP

电泳涂漆工安全操作规程 电泳涂漆工安全操作规程提要：悬链运行前，应对拉紧装置进行调整，检查回转线上是否有障碍物，运转是否正常。电泳过程中自来水不得进入泳池内 源自物业管理资料 电泳涂漆工安全操作规程 1．检查吊运设备，工具和吊挂用具是否有缺陷或损坏。 2．向酸洗槽倒酸时，必须使用专用工具，并要戴口罩和橡皮手套，以免灼伤。除操作者外，其他人必须远离酸槽约一米左右。 3．装酸的容器要放在空旷处，瓶盖不得盖得过紧，防止蒸发的气体聚积在容器内引起爆炸。 4．配酸后，应将装酸容器盖好，防止水进入酸中发生危险。 5．酸槽溶液深度不能超过槽深的3／4，以免酸液溢出灼伤皮肤。 6．酸液的温度不宜太高，盐酸不许高于35℃，硫酸温度不许高于65℃，防止分解出有害蒸气。 7．悬链运行前，应对拉紧装置进行调整，检查回转线上是否有障碍物，运转是否正常。电泳过程中自来水不得进入泳池内。如遇停电，应立即将悬链停车。 8．电热烘道各段温度应严格按规定值调节，发现温度异常及烘道烟气外冒，应停止工作，请电工检查。 9．采用煤气烘干，应先检查各阀门是否关闭紧固。点火前将炉内余气吹净，打开冷却水管。点火时先点燃引火棒，再开煤气引燃烧嘴，然后调节空气阀和煤气阀使之充分燃烧。关炉操作与开炉顺序相反。关炉后10～20分钟再关闭风机和冷却水管。 10．工作中禁止攀登或站在酸槽的边缘上进行工作。 11．发现火警时，应立即报告并采取补救措施。 12．工作完毕后，断开电源，关闭气门，做好清洁。 源自物业管理资料 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work, set a good XX students ideological quality, psychological quality and image quality. The formation of excellent moral education c