EBZ160掘进入井流程管理规定.docVIP

EBZ160掘进机入井流程管理规定 为规范EBZ160掘进机的入井管理，现需将掘进机从地面（液压车间）运至井下工作面，为确保掘进机安全顺利的运输到指定地点，需对掘进机地面拆卸、装车、封车、井下运输、安装、回收等一系列工序制定详细的管理规定，具体规定如下： 一、地面拆卸 1、拆卸必须由综掘队机电队长现场统一指挥，由专人拆卸，要严格按照安装使用说明书规定拆卸。 2、拆卸前，综掘队要准备10T、5T的吊链各一个，撬棍、道木、钢丝绳等配套设施。 3、拆卸时，组织人员要熟知各部件的重量，用吊链把拆卸的部件吊至一个水平面进行拆卸，所有部件要用吊车平稳放在车场附近。 4、部件起吊时，钢丝绳部件连接要可靠，吊链起吊要有专人指挥，严禁在其他人员在附近进行其他作业。 5、拆卸下的螺栓，垫圈，销子等小东西要妥善分类保管，防止混淆和丢失，且存放的地方必须干净。 6、拆卸下的部件要轻拿轻放，拆下的液压管件及接口要用棉纱塞好和保护好，柱塞等精密件要加包装，记清管接头号。 7、电器设备下井前，所有喇叭口都必须封好，确保绝缘良好。 7、拆卸后的大件分别为：截割部、铲板部、本体部、行走部（2件）、刮板机、操作台、后支撑座、转载机九大件。 三、地面装车、封车 1、掘进机解体专用平板车准备12辆，道木20块。 2、掘进机大件全部采用平板车单车装运所有固定连接钢丝绳必须确保完好无损，固定连接过程中出现破损必须重新更换封车材料。必须一名长以上管理人员现场指挥特种”及“应急车辆”运送管理办法the economic development in the new normalOf awareness errors, deep awareness economic development new normal of objective inevitability, prevent one-sidedness, and simplistic, cannot to whether on himself favourable to judge new normal bad; cannot put new normal as a basket, what are to in loaded; cannot put new normal as haven, put work bad do, and didnt dry good of reasons are due Yu new normal, for not officer, and not development find excuses. Actively promote the supply side of structural reforms and implement the CPC Central Committee defined five pillars of policy and five priorities, implement the major decisions and arrangements of the central support accelerated development of Fujian, a good grasp of the old Soviet areas, green development, precision significant opportunities to alleviate poverty. (4) lead to overcome difficulty, dare to play. Dare not sword, before major problems before not to grasp the nettle and on front, afraid to come forward before the crisis and error cant bear responsibility, not firmly fight these issues before the evil, strengthen the sense of responsibility, to take charge. Dont want to under the new situation, not as good as issues, enhance vigor, growing new skills, new, do dry dry dry active, do we want to do good, to take Shi Liuyin, grasping the iron mark strength and hard work together create a men