8V92故障原因.docVIP

问题 POSSIBLE REASON可能原因 CHECK入住 Engine will not start 发动机将无法启动 Lack of air intake or restricted air intake缺乏空气摄入量或限制的进气口 √ √ Broken blower shaft残破的风机轴 Worn out blower shaft废旧风机轴 Defective fuel pump燃油泵有故障 Defective starter有缺陷的起动 Discharged battery放电的电池 High exhaust back pressure高排气背压 Black smoke coming out of engine 黑色冒烟的发动机 Defective injector有缺陷的喷油器 Contaminated fuel污染燃料 Broken or worn cylinder parts缸部分损坏或磨损 Engine overloaded发动机超负荷 Faulty intercooler or aftercooler for turbo engines only 错误的冷却器或冷却器（仅适用于涡轮增压发动机） White smoke coming out of engine 白烟发动机 Broken piston ring损坏的活塞环 Incorrectly installed ring set安装不正确的戒指 Defective injector有缺陷的喷油器 Fuel quality or grade燃料质量或档次 Long idle periods长期闲置期 Broken or bent push rod折断或弯曲的推杆 Injector or governor improperly adjusted注射器或总督调整不当 Low engine oil pressure 发动机机油压力低 Water in engine oil pan水在发动机油底壳 Fuel in engine oil pan燃料发动机油底壳 Defective oil cooler有缺陷的机油冷却器 Engine overloaded发动机超负荷 Crankcase overfilled曲轴箱装得太满 Low engine RPM 发动机转速低 Improperly working injector不正确的工作喷油器 Governor calibration总督校准 Hi engine RPM 高发动机转速 Governor calibration总督校准 Engine overheating 发动机过热 Defective fresh water pump缺陷淡水泵 Defective raw water pump marine engines only 有缺陷的原水泵（仅适用于船用发动机） Defective thermostat or thermostat seal有缺陷的温控器或温控器密封 Clogged radiator or heat exchanger marine engine only 堵塞散热器或热交换器（船用发动机） Grey smoke coming out of engine 灰色烟雾的发动机 Long idle periods长期闲置期 Defective intercooler or aftercooler for turbo engine only 破损的冷却器或冷却器（仅用于涡轮增压发动机） Restricted air intake受限制的进气口 Defective injector有缺陷的喷油器 Contaminated fuel污染燃料 Blower or turbocharger seals leaking散热或涡轮增压器密封泄漏 Geartrain makes noises Geartrain发出噪音 Low oil level低油位 Engine driven accesories引擎驱动饰品 Damage main or rod bearing主或连杆轴承损坏 中山骏昊塑胶五金制品有限公司 /default.asp